Any part of the concrete mixer has an important role in it, but inevitably, the equipment used for a long time, parts will suffer such damage, such as belt damage, so what is caused? How do you do that?

　　原因：金屬皮帶清掃器如不及時調整，容易損傷皮帶，造成皮帶表面橡膠脫落。清掃器安裝不正確，比較尖的碎石卡在清掃器之間會損傷皮帶?；炷翑嚢铏C的皮帶本身質量不好，也容易出現上述缺陷。

　　Cause: If the metal belt sweeper is not adjusted in time, it is easy to damage the belt and cause the rubber on the belt surface to fall off. The sweeper is not installed correctly, and sharp gravel stuck between the sweeper will damage the belt. The belt quality of the concrete mixer itself is not good, but also prone to the above defects.

　　處理：混凝土攪拌機的皮帶一旦出現脫膠、開裂、劃傷等缺陷，應及時修補。當皮帶出現損傷時，要造成皮帶損傷的因素，如清掃器損壞，則需立即調整或更換清掃器，然后及時修補皮帶。

　　Treatment: once the concrete mixer belt degumming, cracking, scratches and other defects, should be repaired in time. When the belt is damaged, the factors causing the belt damage should be solved first. If the sweeper is damaged, it is necessary to adjust or replace the sweeper immediately, and then repair the belt in time.

　　皮帶損傷很小時，可用皮帶修補膠現場修補。當皮帶損傷面較大或局部損壞嚴重時，可把局部損傷的皮帶切除掉，更換一段皮帶，用硫化機進行膠結。如皮帶損傷不及時處理，損傷蔓延到整條皮帶時，則沒有修復價值，只能整條更換。

　　Belt damage is very small, can be repaired on the spot with belt repair glue. When the belt damage surface is large or the local damage is serious, the local damage of the belt can be cut off, replace a belt, with vulcanizing machine for cementation. If the belt damage is not dealt with in time, the damage spread to the whole belt, there is no repair value, can only be replaced as a whole.

　　所以在日常的使用中，設備的操作人員要每天檢查皮帶運轉是否對中，發現跑偏應及時調整，避免皮損壞；檢查皮帶清掃器的使用效果，及時調整或更換清掃器;檢查托輥、滾筒上是否粘料，如有粘料應及時清理掉；皮帶表面是否有損傷，如有損傷跡象應及時修補，避免損傷蔓延。

　　Therefore, in daily use, the operator of the equipment should check whether the belt operation is in the right every day, and adjust the deviation in time to avoid skin damage; Check the use effect of belt sweeper, adjust or replace the sweeper in time; Check whether there is sticky material on the idler and roller, if there is sticky material, it should be cleaned up in time; Whether there is any damage on the surface of the belt, if there is any sign of damage should be repaired in time to avoid the spread of damage.

　　以上內容就是小編給大家介紹的混凝土攪拌機皮帶怎么損傷的，做好設備的保養工作才能提高其使用壽命以及減少機器故障發生的頻率，用戶一定要予以重視。更多詳情請來我們網站http://www.gdfcx.net咨詢吧！

　　The above content is xiaobian to introduce how the concrete mixer belt damage, do a good job of equipment maintenance work to improve its service life and reduce the frequency of machine failure, the user must pay attention to. Please visit our website http://www.gdfcx.net for more details!