混凝土攪拌機是用來運送建筑用混凝土的專用卡車，隨著商品混凝土的產生而產生和發展的，它了商品混凝土從制備地點到澆注現場的運輸問題，因此成為商品混凝土的理想運輸工具。那么混凝土攪拌機裝料運輸期間要做的事情是怎樣的呢？

Concrete mixer is a special truck used to transport construction concrete. With the emergence and development of commercial concrete, it solves the transportation problem of commercial concrete from the preparation site to the pouring site, so it has become an ideal transportation tool of commercial concrete. So what should be done during the loading and transportation of concrete mixer?

裝料前應先將攪拌筒反轉

Reverse the mixing drum before loading

車輛頭班運行時盡可能先反轉，因大多是露天停放，罐里可能會有積水、樹葉等雜物，如不排出將影響混凝土質量。

During the first shift operation, the vehicle shall be reversed as far as possible, because most of them are parked in the open air, there may be ponding, leaves and other sundries in the tank, which will affect the concrete quality if not discharged.

裝完料要記得沖洗進料斗

Remember to flush the feed hopper after loading

要不然裝料時散落的小石子容易凝固在接料斗內外和溜槽上，影響使用和美觀。

Otherwise, the small stones scattered during loading are easy to solidify inside and outside the receiving hopper and on the chute, affecting the use and beauty.

運輸中拐彎的時候一定要慢

Be sure to turn slowly during transportation

攪拌車高，易側翻！入彎之前提前減速減擋，盡量別拐彎的時候踩剎車。隨時通過后視鏡注意觀察罐子是否在轉，把轉速盡量調慢，轉速過高，車輛容易擺動。

The mixer truck has a high center of gravity and is easy to roll over! Decelerate and downshift in advance before turning, and try not to step on the brake when turning. Observe whether the can is rotating through the rearview mirror at any time. Slow down the speed as much as possible. If the speed is too high, the vehicle is easy to swing.

不好的路面低速擋通過

Low speed transmission on bad roads

遇到路面不平、坑坑洼洼地方用合適的低速擋通過，保證車子的動力充沛。遇到大坑，石頭，鋼筋，鐵塊盡量避讓，尤其重車。

In case of uneven and potholes on the road, pass through with appropriate low gear to ensure sufficient power of the car. Try to avoid big pits, stones, steel bars and iron blocks, especially heavy vehicles.

上坡建議是提前減檔

The suggestion for uphill is to downshift in advance

如果拉得滿的話，注意起步要平緩，上坡更要注意，不能亂減擋，建議提前減擋。同時，建議加快罐子的轉速，已免混凝土流出。

If it's full, pay attention to a gentle start and pay more attention when going uphill. Don't reduce gears randomly. It's recommended to reduce gears in advance. At the same time, it is suggested to speed up the rotation speed of the tank to prevent the concrete from flowing out.

下坡切勿重車空擋滑行

Do not slide with the loaded vehicle in neutral gear downhill

長時間行駛或者下坡前都要掛入合適檔位行駛。切勿重車空擋滑行下坡。下坡拐彎時提前減速然后再減擋再減速，帶擋剎車效果建議。

Shift into the appropriate gear before driving for a long time or going downhill. Do not slide down the slope with the loaded vehicle in neutral. When turning downhill, decelerate in advance, then reduce the gear, and then decelerate. It is recommended to stop the braking effect.

一定要注意限高問題

Be sure to pay attention to the height limit

工地路況復雜，要小心樹木等，特別是要防止刮到電線。

The road conditions on the construction site are complex, so be careful of trees, especially to prevent scraping wires.

由于混凝土攪拌機的大規模使用，許多用戶對一些日常的使用和維護了解不多，攪拌車的工作環境又比較惡劣，再加上用戶不注意日常保養，就造成了一些不必要的故障和經濟損失。在維護和修理方面必須遵照規定，執行“定期檢測、強制維護、視情修理”的維護和修理制度。在這個大前提下，再結合混凝土攪拌機的實際情況，做好維護和修理。

Due to the large-scale use of concrete mixer, many users do not know much about some daily use and maintenance, and the working environment of mixer truck is relatively poor. In addition, users do not pay attention to daily maintenance, which has caused some unnecessary faults and economic losses. In terms of maintenance and repair, the maintenance and repair system of "regular inspection, compulsory maintenance and repair as appropriate" must be implemented in accordance with the regulations. On this premise, combined with the actual situation of the concrete mixer, do a good job in maintenance and repair.

混凝土攪拌機裝料運輸期間要做的事情相關內容便是這樣了，您可以關注我們的網站www.gdfcx.net，了解更多的內容信息。

This is what should be done during the loading and transportation of concrete mixer. You can pay attention to our website www.gdfcx.net COM, learn more content information.