事實上任何一個機器設備在使用之前都要求操作人員按照相關內容來進行操作，這樣做自然是為了保障操作人員的以及機器設備的正常運行，混凝土攪拌機也不例外，那么它的操作要符合哪些相關內容才合適呢？

　　In fact, any machine equipment before use requires the operator to operate in accordance with the relevant content, so it is natural to ensure the safety of the operator and the normal operation of the machine and equipment, the concrete mixer is no exception, so its operation should conform to the relevant content is appropriate?

　　在使用前應進行一次空運轉試機，在試機前應先檢查混凝土攪拌機全部連接件的堅固程度，減速器內的潤滑油油量和電器設備的完整性然后閉合總開關，通入電源，進行空運轉試機。

　　Before use, an empty operation test machine should be carried out. Before the test machine, it should first check the firmness of all connecting parts of the concrete mixer, the amount of lubricating oil oil in the reducer and the integrity of electrical equipment. Then close the total switch, access to the power supply, and carry out the empty operation test machine.

　　空運轉試機試驗。在未發現不正常的響聲、軸承檔發高熱、減速器溫度直升等不良現象的情況下，才可使混凝土攪拌機投入生產。在運轉中如需鏟刮機內桶壁物料，應用竹木器工具，切不可用手，以免造成傷手事故。

　　Air running test machine test. The concrete mixer can be put into production only when abnormal sound, high heat of bearing file and temperature helicopter of reducer are not found. In operation, if you need to shovel and scrape the material of the barrel wall of the machine, use bamboo tools, do not use hands, so as not to cause hand injuries.

　　在使用中如發現機器震動異?；虬l出不正常怪聲，應立即停掉混凝土攪拌機進行檢查。

　　If any abnormal vibration or abnormal sound is found during use, the concrete mixer should be stopped immediately for comprehensive inspection.

　　使用負荷不要過大，一般以電動機的負荷來測定，用380V電動機在攪拌塑料時的重載電流，以不超過6安培為正常，如超過負荷應立即減少攪拌容量。

　　The use load should not be too large, generally measured by the load of the motor, the heavy current of the 380V motor when mixing plastic is not more than 6 amperes as normal, such as exceeding the load should immediately reduce the mixing capacity.

　　攪拌螺桿兩端軸封應保持清潔，以免造成塑料發黑、變質，大攪拌桶體兩端外檔留有方孔，應通暢，切勿使混凝土攪拌機之堵塞，以免起反壓力作用，使污物滲入軸心，使大桶內物料發黑、變質。

　　Mixing screw at both ends of the shaft seal should be kept clean, so as not to cause plastic black, deterioration, large mixing barrel body at both ends of the file left square hole, should be unblocked, do not make the concrete mixer blocked, so as not to backpressure effect, so that the dirt into the shaft, so that the barrel material black, deterioration.

　　管理人員必須熟悉混凝土攪拌機的技術性能、內部構造、控制結構及使用原理。運轉期間不得離開工作地點，防止發生故障而損壞機件，以保證生產為前提。

　　Management personnel must be familiar with the technical performance, internal structure, control structure and operating principle of concrete mixer. During operation, do not leave the working place to prevent failure and damage to the parts, in order to ensure safe production as the premise.

　　打開電源，打開混色機蓋子，用手按住保護開關，然后按下綠色啟動開關，注意留意電機轉向(順時針旋轉)，如果方向反了，請按下紅色開關停機并關閉電源，調換任意兩根火線位置接線便可。

　　Turn on the power, open the cover of the color mixer, press the safety switch with your hand, then press the green start switch, pay attention to the motor turning (clockwise rotation), if the direction is opposite, please press the red switch to stop and turn off the power, exchange any two live wire position wiring.

　　確認混凝土攪拌機電機轉向正確之后便可正常投入生產，請根據不同物料所需混色時間設定好時間后(定時器0~30分鐘可調)進行生產使用。

　　After confirming that the motor of concrete mixer turns correctly, it can be put into production normally. Please set the time according to the mixing time required by different materials (timer can be adjusted from 0 to 30 minutes) for production and use.

　　混凝土攪拌機的操作要符合相關內容才合適的問題就講解到這里了，如果您有糾結的內容可以來網站www.gdfcx.net看看相關咨詢，然后尋求人員的幫助。

　　The operation of concrete mixer should conform to the relevant content. The problem is explained here. If you have tangled content, you can come to the website www.gdfcx.net to see the relevant consultation, and then seek professional help.