General usage of concrete mixer: after the mixer is powered on, start the main mixing motor through the start (stop) switch with protection function. When the equipment enters the normal operation condition, then add the substances to be mixed into the mixing plate of the mixer. At the same time, add a certain amount of water into the mixing plate through the water pump to mix together. After the materials are mixed evenly, Open the material door to discharge. After all the materials in the mixer are discharged, close the material door to complete a mixing cycle. The single-phase submersible pump is selected for water supply. The water supply is timed. After the water supply time is completed, the power will be cut off automatically and the water supply will be stopped. The whole water adding process is simple and easy to operate.

攪拌機通電往后，發動攪拌主電機的運用辦法強力攪拌機進入正常作業狀況后，再將不定型耐火材料參加到攪拌機的混合盤中，與此同時經過加水泵向混合盤內參加必定量的水一同攪拌，待物料攪拌均勻后，擺開料門，經排料溜槽進入小車內，小車可在作業導軌上恣意移動和停留，以滿足主鐵鉤不同方位的加料需求，在攪拌機的物料悉數排凈后，關閉料門，在作業時所有刮板與襯板之間應保持必定的空隙。供水選用單相潛水泵，計時供水，混凝土攪拌機價格供水完成后自動斷電。

After the mixer is powered on, start the main mixing motor. After the strong mixer enters the normal operation condition, the amorphous refractory materials are added to the mixing plate of the mixer. At the same time, a certain amount of water is added to the mixing plate through the water pump to mix together. After the materials are mixed evenly, open the material door and enter the trolley through the discharge chute, The trolley can move and stay freely on the operation guide rail to meet the feeding needs of the main iron hook in different directions. After all the materials of the mixer are discharged, close the material door, and maintain a certain gap between all scrapers and lining plates during operation. The single-phase submersible pump is selected for water supply. The water supply is timed. The concrete mixer will automatically cut off the power after the water supply is completed.

攪拌機帶葉片的軸在圓筒或槽中旋轉，用以混合或揉和物質使成所需稠度的機器。攪拌機分為好多種，有強制式攪拌機、單臥軸攪拌機、雙臥軸攪拌機等等。注意事項：攪拌機及自攪拌機動供料機，必須把里面清洗潔凈，尤其是冬季，這樣能延伸壽數。

A machine in which a bladed shaft rotates in a cylinder or groove to mix or knead substances to the desired consistency. There are many kinds of mixers, including forced mixer, single horizontal shaft mixer, double horizontal shaft mixer and so on. Precautions: the mixer and self mixing motor feeder must be cleaned, especially in winter, so as to extend the service life.

水泥混凝土攪拌機的用處就是機械化的拌制水泥混凝土，其種類較多，分類辦法和特色如下。按作業辦法分有循環作業式和連續作業式兩種。循環作業式的供料、攪拌、卸料三道工序是按必定的時間距離周期進行的，即按份拌制。

The purpose of cement concrete mixer is to mix cement concrete mechanically. There are many kinds. The classification methods and characteristics are as follows. According to the operation method, there are two types: circular operation type and continuous operation type. The three processes of circular feeding, mixing and unloading are carried out periodically according to a certain time distance, that is, mixing by parts.

由于拌制的各種物料都經過準確的稱量，故攪拌質量好?，F在大多選用此種類型的作業辦法。連續作業式的上述三道工序是在一個較長的筒體內連續進行的。盡管其生產率較循環作業式高，但由于各料的合作比、攪拌時間難以控制，故攪拌質量差?，F在運用較少。

Because all kinds of materials are accurately weighed, the mixing quality is good. At present, this type of operation method is mostly used. The above three processes of continuous operation are carried out continuously in a long cylinder. Although its productivity is higher than that of circular operation, the mixing quality is poor because the cooperation ratio and mixing time of each material are difficult to control. It is less used now.

按攪拌辦法分有自落式攪拌、強制式攪拌兩種。自落式攪拌機就是把混合料放在一個旋轉的攪拌鼓內，跟著攪拌鼓的旋轉，鼓內的葉片把混合料提升到必定的高度，然后靠自重自在撒落下來。這樣周而復始地進行，直拌勻中止。這種攪拌機一般拌制塑性和半塑性混凝土。

According to the mixing method, there are two kinds: self falling mixing and forced mixing. The self falling mixer is to put the mixture in a rotating mixing drum. With the rotation of the mixing drum, the blades in the drum lift the mixture to a certain height, and then drop it freely by self weight. This is repeated until the mixing stops. This mixer generally mixes plastic and semi-plastic concrete.

強制式攪拌機是攪拌鼓不動，而由鼓內旋轉軸上均置的葉片強制攪拌。這種攪拌機拌制質量好，生產效率高；但動力消耗大，且葉片磨損快。一般適用于拌制干硬性混凝土。

The forced mixer is that the mixing drum does not move, and the forced mixing is carried out by the blades arranged on the rotating shaft in the drum. The mixer has good mixing quality and high production efficiency; However, the power consumption is large and the blade wear is fast. It is generally suitable for mixing dry and hard concrete.