混凝土攪拌機排出的混凝土干濕不均勻，出現這種情況的可能原因是攪拌時間較短，攪拌不均勻，或者攪拌機噴水管的噴嘴安裝不正確，噴水不均勻，比較容易使混凝土干濕不均。下面來講講詳細內容。

The concrete discharged from the mixer is uneven in drying and wetting. The possible reasons for this are that the mixing time is short, the mixing is uneven, or the nozzle of the mixer's spray pipe is installed incorrectly, and the water spraying is uneven, which is easy to cause uneven drying and wetting of the concrete. Now let's talk about the details.

如何檢查與維修？

How to inspect and repair?

1、檢查攪拌時間是否過短。如果攪拌時間短，可以增加攪拌時間

1. Check whether the mixing time is too short. If the mixing time is short, the mixing time can be increased

2、檢查噴管噴嘴的安裝順序是否正確。

2. Check whether the installation sequence of spray bar nozzle is correct.

混合時間過短，質量肯定得不到保證，攪拌過久，使飼料混合均勻后又因過度混合而導致分層現象。手工拌和時特別要注意的是一些在日糧中所占比例小但會嚴重影響飼養效果的微量成分，如食鹽和各種添加劑。對這類微量成分，在拌和時要充分粉碎，不能有結塊現象。

If the mixing time is too short, the quality will certainly not be guaranteed. If the mixing time is too long, the feed will be mixed evenly and then cause stratification due to excessive mixing. During manual mixing, special attention should be paid to some trace ingredients, such as salt and various additives, which account for a small proportion in the diet but will seriously affect the feeding effect. For such trace components, they should be fully crushed before mixing, without agglomeration.

飼料拌和有機械拌和與手工拌和兩種方法，只要使用得當，都能獲得滿意的效果。無論使用哪種攪拌機，為了攪拌均勻，裝料量都要適宜，裝料過多或過少都無法保證均勻度，一般以容量的60%～80%裝料為宜。

There are two methods of feed mixing: mechanical mixing and manual mixing. If used properly, satisfactory results can be obtained. No matter which type of mixer is used, in order to mix evenly, the charging amount must be appropriate. Too much or too little charging cannot ensure the uniformity, and it is generally appropriate to charge 60%~80% of the capacity.

攪拌機帶葉片的軸在圓筒或槽中旋轉，用以混合或揉和物質使成所需稠度的機器。攪拌機分為好多種，有強制式攪拌機、單臥軸攪拌機、雙臥軸攪拌機等等。

A machine in which a shaft with blades rotates in a cylinder or tank to mix or knead substances to achieve the desired consistency. There are many kinds of mixers, including forced mixers, single horizontal shaft mixers, double horizontal shaft mixers, etc.

使用混凝土攪拌機須把里面清洗干凈，尤其是冬天，這樣能延長壽命。更多相關內容事項就來我們網站http://www.gdfcx.net進行咨詢吧！

When using the concrete mixer, the inside must be cleaned, especially in winter, so as to prolong the service life. Come to our website for more information http://www.gdfcx.net Consult!