小型攪拌機其實也是比較脆弱的，所以我們平時一定要細心保養，才能使用得更長久，下面就教你幾個小技巧。

Small mixers are actually fragile, so we must maintain them carefully in order to use them for a long time. Here are some tips.

做好換季保健工作，要用冬油脂。攪拌機的發動機、變速器、差速箱、轉向機構冬季更換專用潤滑油(發動機油位不超過正常范圍，也不低于低限度)；攪拌機的輪轂軸承等用低凝點潤滑脂代替；柴油車應提前更換冬季適時的柴油，防止惡劣天氣下柴油凍冰。

Do a good job in the health care work in the new season, and the key is to use winter oil. The engine, transmission, differential case and steering mechanism of the mixer shall be replaced with special lubricating oil in winter (the oil level of the engine shall not exceed the normal range nor lower than the low limit); The hub bearing of the mixer is replaced with low freezing point grease; Diesel vehicles shall be replaced with timely diesel in winter in advance to prevent diesel from freezing in bad weather.

檢查攪拌車電瓶的液位和濃度。冬季要注意保暖和充電，電解液要保持一定的比重和充足的電狀態，及時補充電解液或更換電瓶。對保險絲盒進行清洗、檢查，及時更換有隱患的保險絲，保持保險絲清潔，避免冬季天黑時因保險絲出問題車輛拋錨。

Check the liquid level and concentration of the battery of the mixer truck. Pay attention to keep warm and charge in winter. The electrolyte should keep a certain proportion and sufficient electric state. Replenish the electrolyte or replace the battery in time. Clean and inspect the fuse box, timely replace the fuse with hidden dangers, keep the fuse clean, and avoid the vehicle from breaking down due to fuse problems in winter.

檢查、更換攪拌車的火花塞。冬天點火容易出現問題，溫度低，點火能量低，多極火花塞好更換，價格不貴，點火好，能量高。冬天更換攪拌車雨刮片和玻璃水。在玻璃水中加入適當比例的酒精，既能減少冰點，又能防止結冰，是簡便的方法。

Check and replace the spark plug of the mixer truck. Ignition in winter is prone to problems. The temperature is low, the ignition energy is low, the multipole spark plug is easy to replace, the price is not expensive, the ignition is good, and the energy is high. Replace the wiper blade and glass water of the mixer in winter. Adding appropriate proportion of alcohol to glass water can not only reduce the freezing point but also prevent freezing. It is a simple method.

檢查攪拌機離合器的自由移動行程。經常踩踏離合器，經夏季長時間使用，應調整適當的自由行程，使冬季路滑離合更加精確；攪拌車制動液應保持在正常范圍內，調整手剎松緊度，四輪定位，檢查制動系統，保持四輪制動基本一致，防止攪拌車制動液跑偏。

Check the free movement stroke of the mixer clutch. If the clutch is frequently pressed and used for a long time in summer, the appropriate free travel should be adjusted to make the road slip clutch more accurate in winter; The brake fluid of the mixer truck shall be kept within the normal range. Adjust the hand brake tightness, four-wheel positioning, check the brake system, keep the four-wheel brake basically consistent, and prevent the brake fluid of the mixer truck from running off.

勤查攪拌車輪胎及氣壓值。冬天路面摩擦系數低，攪拌車輪胎氣壓不能過高或過低(外溫低，輪胎脆，氣壓低，柔胎狀態會加速輪胎老化)，為確保減少磨損，定期更換輪胎；磨損嚴重、老化的輪胎應及時更新。

Frequently check the tire and air pressure of the mixer. In winter, the friction coefficient of the road surface is low, and the tire pressure of the mixer shall not be too high or too low (the outer temperature is low, the tire is brittle, the air pressure is low, and the soft tire state will accelerate the aging of the tire). In order to ensure safety and reduce wear, the tire shall be replaced regularly; The tires with severe wear and aging shall be updated in time.

更換油濾嘴，目的在于減少機件內部雜質、水分(冬季較易附著在機件上)對油路的影響；檢查、清洗、更換攪拌車空氣濾清器濾芯，以減少攪拌車發動機吸氣阻力，增加混合氣入口，降低油耗，提高功率。更多注意事項就來關注我們網站http://www.gdfcx.net！

The purpose of replacing the oil filter is to reduce the influence of impurities and moisture inside the parts (it is easy to attach to the parts in winter) on the oil path; Check, clean and replace the air filter element of the mixer truck to reduce the suction resistance of the mixer truck engine, increase the inlet of the mixed gas, reduce the fuel consumption and improve the power. For more notes, please follow our website http://www.gdfcx.net ！