很多人都把自動混凝土攪拌機看成賺錢的工具，只知道使用，卻忽略了出車前的正確準備事項，很大可能會在某出現故障危及，下面來講講相關事項。

Many people regard the automatic concrete mixer as a tool to make money. They only know how to use it, but they ignore the correct preparations before driving. It is likely that some day there will be a failure endangering the safety. Let's talk about the relevant matters below.

檢查、發現問題排除故障

Check, find problems and troubleshoot

攪拌車害怕在路上罐子不轉，混凝土一般停罐不能超過2個小時，C40以上級別的混凝土在路上罐子就不能停。車子啟動后，先讓罐子低速旋轉，圍繞著車檢查輪胎氣壓，看是否有漏氣的胎，檢查是否有石子、鐵釘之類扎在胎里，及時清理干凈。檢查側燈務必保證照著輪胎邊緣，因為工地會經常亂堆放鋼筋之類雜物，而胎側是薄弱的。

The mixer truck is afraid that the tank will not turn on the road. Generally, the concrete can not be stopped for more than 2 hours, and the concrete above C40 can not be stopped on the road. After the car starts, let the tank rotate at a low speed. Check the tire pressure around the car to see if there is a flat tire. Check if there are stones, nails, etc. stuck in the tire. Clean it up in time. When checking the side lamp, make sure to shine on the edge of the tire, because the construction site will often pile up reinforcement and other sundries, and the tire side is weak.

保證水箱里有足夠的水，有減水劑

Ensure that there is enough water and water reducer in the water tank

因各種原因料太干，沒有水添加放不出料的時候，減水劑就是救命稻草了，可以保證混凝土的流動性。

The material is too dry for various reasons. When there is no water to add and the material cannot be discharged, the water reducer is a lifesaving straw, which can ensure the fluidity of concrete.

確認攪拌罐處于停止狀態

Confirm that the mixing tank is stopped

因為發動機啟動時萬一罐子處于高速旋轉狀態，瞬間的力會很大的，傷減速機和泵馬達系統。

If the tank rotates at a high speed when the engine starts, the instantaneous force will be great, which will damage the reducer and pump motor system.

檢查特別注意事項

Special precautions for inspection

減速機齒輪油，液壓系統（馬達、油泵、散熱器）的油初次工作100小時更換，以后每1000小時更換（每年少更換1次）。散熱器、傳動軸、滾道、拖輪、主槽轉軸、操縱桿每月加注一次黃油。

The gear oil of the reducer and the oil of the hydraulic system (motor, oil pump, radiator) shall be replaced after 100 hours of operation for the first time, and then every 1000 hours (at least once a year). Grease the radiator, transmission shaft, raceway, tugboat, main slot shaft and control lever once a month.

自動混凝土攪拌機出車前就是要知道以上所講解的內容，這只是事項的一部分，更多更為詳細的操作您可以隨時來我們網站http://www.gdfcx.net聯系做對接。

Before the automatic concrete mixer is delivered, you should know what is explained above. This is just a part of the matter. For more detailed operations, you can come to our website at any time http://www.gdfcx.net Contact for docking.